Upper Attachment of the Galley 6475MM at Location 1 Figure 403/TASK 25-31-41-991-018
R EFF : 001-049, 101-105, 25-31-41 Page 422 May 01/05
CES
DAMAGED OR INJURE PERSONNEL. THE UNIT/ASSEMBLY IS
HEAVY.
1_ Carefully lift the galley off the blocks (15) and move it to
the center of the aircraft.
____ installation procedure.
(i)
Remove the blocks (15).
(j)
Remove and discard the packings (16).
(k) Remove the bushes (17). Subtask 25-31-41-020-050
B. Disconnect the Galley Splitline NOTE : This procedure is only necessary if you must remove the galley
____
from the cabin. NOTE : The splitline screws and bolts are painted red.
____
R R Upper Attachment - G1 Figure 403A/TASK 25-31-41-991-018-C
R EFF : 051-099, 25-31-41 Page 424 May 01/05
CES
Upper Attachments - G1 Figure 403B/TASK 25-31-41-991-018-A
R EFF : 106-149, 201-299, 25-31-41 Page 425 May 01/05
CES
R Upper Attachments - G1 Figure 403C/TASK 25-31-41-991-018-B
R EFF : 151-199, 25-31-41 Page 426 May 01/05
CES
Lower Attachment of the Galley 6475MM at Location | Figure 404/TASK 25-31-41-991-019
R EFF : 001-049, 101-105, 25-31-41 Page 427 May 01/05
CES
(1) Disconnect the Galley at the Splitline (Ref. Fig. 405/TASK 25-31-41-991-020)
(a) Remove the electrical connectors (9).
(b) Remove the nut (8), the washer (7).
(c) Remove the ground wire (6) from the stud (5).
(d) Remove the screws (11) and the washers (10) from the cart bumper (12).
(e) Remove the cart bumper (12) from the cart stowage compartment.
(f) Remove the bolts (1).
(g) Remove the screws (4) and and the panels (3).
(h) Remove the bolts (2).
WARNING : SUPPORT THE UNIT/ASSEMBLY OR IT WILL FALL AND BECOME_______ DAMAGED OR INJURE PERSONNEL. THE UNIT/ASSEMBLY IS HEAVY.
(i) Carefully separate the galley modules.
(j) Carefully lift and remove the modules from the aircraft.
R **ON A/C 051-099,
R Subtask 25-31-41-020-062-C
R A. Removal of the Galley Unit
R R (1) Remove the Power Supply (Ref. Fig. 401A/TASK 25-31-41-991-038-C)
R R R WARNING : WEAR GOGGLES WHEN YOU REMOVE OR INSTALL THE LOCKWIRE. CUT,_______ REMOVE AND DISCARD THE LOCKWIRE AS YOU DO THE TASK. LOOSE LOCKWIRE CAN CUT OR BLIND YOU.
R R R R CAUTION : MAKE MATCH MARKS ON ALL THE ELECTRICAL WIRES BEFORE YOU_______ DISCONNECT THEM. IF YOU MAKE AN ERROR WHEN YOU CONNECT THE WIRES YOU WILL CAUSE DAMAGE TO EQUIPMENT.
CES
R R Lower Attachment - G1 Figure 404A/TASK 25-31-41-991-019-C
R EFF : 051-099, 25-31-41 Page 429 May 01/05
CES
Lower Attachment - G1 Figure 404B/TASK 25-31-41-991-019-A
R EFF : 106-149, 201-299, 25-31-41 Page 430 May 01/05
CES
R Lower Attachments - G1 Figure 404C/TASK 25-31-41-991-019-B
R EFF : 151-199, 25-31-41 Page 431 May 01/05
CES
Galley Splitline Figure 405/TASK 25-31-41-991-020
R EFF : 001-049, 101-105, 25-31-41 Page 432 May 01/05
CES
R (a) Remove and discard the lockwire from the screws (6).
R (b) Loosen the screws (6) and remove the cover (7).
R (c) Remove the nuts (5) and the wires (4).
R (d) Remove the nuts (3), the washers (2) and release the clamps (1)
R from the wires.
R (e) Remove the bolts (8) and the washers (9).
R (f) Release the clamps (10) from the wires.
R (g) Remove the nut (14), the bolt (12), the washer (13) and the
R bonding straps (11).
R (2) Disconnect the Potable and Drain Water Connections
R (Ref. Fig. 402A/TASK 25-31-41-991-014-C)
R WARNING : MAKE SURE THAT THE POTABLE WATER SYSTEM IS DEPRESSURIZED. A_______
R PRESSURIZED SYSTEM CAN CAUSE INJURY TO PERSONS WHEN THEY DO
R WORK ON IT.
R (a) Open the door (1).
R (b) Remove the screws (2) and the access panel (3).
R (c) Push up the insulation (4) and remove the clamps (6) from the
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：A320飞机维护手册 AMM EQUIPMENT/FURNISHINGS 设备3
