49-52-00
ALL ú ú 02 Page 1 ú Nov 15/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / GTCP85-129 SERIES /737-300/400/500/ ENGINES /MAINTENANCE MANUAL ////////////////////////
UPPER SHROUD CONTROL LINE FOR THE BLEED AIR SEE C SEE A
AIR DUCT BLEED
FWD
TURBINE PLENUM SEE B
A
CONTROL LINE FOR THE BLEED AIR BLEED AIR VALVE SOLENOID
AIR DUCT BLEED ELECTRICAL PLUG
CONTROL AIR LINE
VALVE BLEED AIR AIRPLANE DUCT PNEUMATIC
AIR INLET LINE INBD
DIFFERENTIAL REGULATOR B Figure 1 (Sheet 1) APU Bleed Air System Component Location PRESSURE FWD
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
49-52-00
ALL ú ú 01 Page 2 ú Mar 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
FORWARD OVERHEAD PANEL, P5
SEED
FLIGHT COMPARTMENT
APU CONTROL
THERMOSTAT
RECIRC FAN
OFF
THERMOCOUPLE NORMAL
PROBE
UPPER 40 60
SHROUD OVHT
80
PSI
0 100
EXHAUST TEST
PORT L PACK ISOLATION R PACK
SURGE BLEED OFF VALVE OFF
VALVE NORMAL CLOSE NORMAL
HIGH AUTO HIGH
CONTROL LINE
AIR LOAD FOR THE BLEED ICE ANTI WING TRIP OFF PACK OPEN TRIP OFF PACK ICE ANTI WING
WING-BODY TRIP WING-BODY
OVERHEAT OVERHEAT
BLEED BLEED
TRIP OFF TRIP OFF
RESET
OFF OFF
3-WAY
SOLENOID ON ON
VALVE 1 BLEED APU 2
FWD BLEED AIR
SWITCH
C D
APU Bleed Air System Component Location
Figure 1 (Sheet 2)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. AIRPLANES WITHOUT ETC ú
49-52-00
ú ú 01 Page 3 ú Mar 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / GTCP85-129 SERIES /737-300/400/500/ ENGINES /MAINTENANCE MANUAL ////////////////////////
FORWARD OVERHEAD PANEL, P5
SEED
FLIGHT COMPARTMENT
RECIRC FAN OFF
ETC NORMAL
THERMOCOUPLE PROBE 40 60 OVHT 80
PSI 0 100
UPPER
SHROUD
TEST
L PACK R PACK
ISOLATION OFF VALVE OFF
EXHAUST
NORMAL CLOSE NORMAL PORT
HIGH AUTO HIGH
WING WINGPACKPACK OPENANTI ANTI
TRIP OFF ICE TRIP OFF ICE
SURGE BLEED
WING-BODYWING-BODY TRIP OVERHEATOVERHEAT
VALVE
BLEED TRIP OFF BLEED TRIP OFF
3-WAY
RESET SOLENOID
OFF OFF
VALVE
ON ON 1 APU 2 BLEED FWD
BLEED AIR C SWITCH
D
APU Bleed Air System Component Location
Figure 1 (Sheet 3)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. AIRPLANES WITH ETC ú
49-52-00
ú ú 01 Page 4 ú Nov 15/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
B. When the APU engine speed is more than 95%, the solenoid for the bleed air valve is energized. When the solenoid for the bleed air valve is not energized, the switcher valve moves the control air to the bottom of the actuator diaphragm. This keeps the main valve closed. Control air from upstream of the main valve moves to the two sides of the diaphragm of the rate control valve. The pressure of the two sides of the diaphragm is the same. This keeps the poppet valve closed. When the BLEED AIR switch is moved to the ON position, the solenoid for the bleed air valve is energized. This opens the check valve and closes the switcher valve. Also, the control air from the bottom of the actuator diaphragm moves to the top of the actuator diaphragm and opens the main valve. When the main valve opens, the pressure at the rate control valve will decrease in proportion to the quantity of bleed air from the APU. Since the adjustable orifice keeps to a limit the bleed air from the top of the rate control diaphragm, the rate control diaphragm will move down and open the poppet valve. Control air will bleed from the actuator to control the rate that the main valve opens. Also, this controls how much the main valve opens to prevent an overload on the APU. While the pressure of the control air bleeds from the top of the rate control diaphragm, the poppet valve will close slowly. While the poppet valve closes, the pressure from the control air in the actuator will increase and open the main valve more. When the poppet valve is fully closed, the main valve is fully open. The adjustable orifice is usually set to make the main valve open in 12 to 14 seconds.
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：737-300 400 500 AMM 飞机维护手册 AIRBORNE AUXILIARY POWER 2(75)
