R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 549 1 1 Config-1 May 01/05 1 1 1CES 1R (4) Make sure that the fluid level in the Blue hydraulic reservoir is not R below the low level warning. R
-------------------------------------------------------------------------------ACTION RESULT -------------------------------------------------------------------------------
R 1. On the test set:
R
R - push the lamp test switch.
R 2. On the test set:
-set the aircraft selector switch to the A320 position.
R 3. On the test set:
R
R - set and hold the PUMP/SPIN
R speed indicator switch for
R approximately 20 seconds in the
R SPIN position.
R
R
R
R
R
R If the green indicator light is
R on:
R - continue with the step 8. of
R this test.
R If the green indicator light is
R not on:
R - continue the test as follows:
R 4. On the test set:
R - release the PUMP/SPIN speed
R indicator switch.
On the test set:
-all the lamps come on.
On the ECAM lower DU:
-
the pressure of the Blue hydraulic system decreases to approximately 2500 psi (172.3689 bar).
At the RAT:
-
the RAT turns.
On the test set:
-
the green indicator light can come on.
At the RAT:
-the RAT stops.
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 550 1 1 Config-1 May 01/05 1 1 1CES 1
-------------------------------------------------------------------------------ACTION RESULT -------------------------------------------------------------------------------
R R R R 5. Pressurize the Blue hydraulic system with the Blue electric pump (Ref. TASK 29-10-00-863-003).
R R R R R R NOTE : The operation of the Blue____ electric pump at the same time as the ground power cart is necessary to supply the RAT with a sufficient flow.
R R R R 6. On the test set: - set and hold the PUMP/SPIN speed indicator switch in the SPIN position.
R 7. On the ground power cart:
R R R R R R R CAUTION : STOP THE TEST_______ IMMEDIATELY IF THE RAT DOES NOT TURN AT ITS CORRECT SPEED IN 20 SECONDS. IF NOT THERE IS A RISK OF DAMAGE TO THE RAT.
R R R R - increase the pressure to 2800 psi (193.0531 bar) (pressure on the HYD page on the ECAM lower DU)
R R R
R R R
R R R R
At the RAT:
-
the RAT turns at its normal speed (5210 to 5590 rpm) in less than 20 seconds.
On the test set:
-
the green indicator light comes on and stays on.
NOTE : The RAT speed stays almost
____ constant, between 5210 and 5590 rpm.
On the ground power cart:
-the pressure must be 206 bar (2987.7766 psi) + 3 bar (43.5113 psi)
-0 bar (0.0000 psi),
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 551 1 1 Config-1 May 01/05 1 1 1CES 1
-------------------------------------------------------------------------------ACTION RESULT -------------------------------------------------------------------------------
R
R
R
R 8. On the test set:
R - release the PUMP/SPIN switch.
R
R
R 9. If the results of the test are
R not correct, do the subsequent
R steps in their sequence until you
R find the fault. Then do the test
R again:
R
R - make sure that the CONTROL UNIT
R - RAT is correctly connected to
R the RAT control panel
- do a check of the electrical
connection of the solenoid
R valve of the RAT ground check
R module
R - replace the RAT ground check
R module (Ref. TASK 29-22-52-000-
R 001) and (Ref. TASK 29-22-52-
R 400-001)
R
R - replace the RAT (Ref. TASK 29-
R 22-51-000-001) and (Ref. TASK
R 29-22-51-400-001).
-
the flow must be between 70 l.min (18.4918 USgal.mn) and 75 l.min (19.8127 USgal.mn).
On the test set:
-
the green indicator light goes off,
-
the amber OIL PRESSURE indicator light comes on for some seconds, (the pump changes from the motor to the pump mode)
-
the RAT speed decreases and stops.
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 552 1 1 Config-1 May 01/05 1 1 1CES 1
R **ON A/C 001-049, 051-061, 101-105, 201-203,
R Post SB 29-1111 For A/C 001-049,051-061,101-105,201-203,
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：A320飞机维护手册 AMM HYDRAULIC POWER 液压5(127)
