79-21-04
ALL ú ú C01 Page 402 ú Mar 15/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
"OIL IN" TUBE
SEE B ELECTRICAL CONNECTOR
CLOGGING
"OIL OUT" TUBE
INDICATOR 0-RING
FILTER ELEMENT
0-RING FWD
BOWL
B
Scavenge Oil Filter - Element Installation Figure 401 (Sheet 2)
C36599
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
79-21-04
ALL ú ú C01 Page 403 ú Mar 15/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
S 944-003-C00
WARNING:_______DO NOT LET THE ENGINE OIL STAY ON YOUR SKIN. IF THE ENGINE OIL STAYS ON YOUR SKIN, INJURY CAN OCCUR.
BE CAREFUL AROUND THE ENGINE OIL SYSTEM IMMEDIATELY AFTER ENGINE SHUT-DOWN. THE ENGINE OIL TEMPERATURE STAYS HIGH FOR SOME TIME AFTER THE ENGINE SHUT-DOWN AND CAN CAUSE INJURY.
CAUTION: IMMEDIATELY CLEAN OFF ALL ENGINE OIL THAT FALLS ON THE PAINTED
_______ SURFACES AND RUBBER PARTS OF THE AIRPLANE. THE SPECIFIED OIL FOR THIS OIL SYSTEM WILL CAUSE DAMAGE TO THE PAINTED SURFACES AND SOME TYPES OF RUBBER AND MUST NOT BE PERMITTED TO TOUCH THESE PARTS OF THE ENGINE.
USE VERY CLEAN CONTAINERS AND EQUIPMENT. OIL CONTAMINATION BY SMALL QUANTITIES OF SOME ALKALINE CLEANERS CAN CAUSE A FAILURE OF THE SYNTHETIC OIL.
DO NOT PUT THE OIL THAT IS DRAINED FROM THE ENGINE BACK INTO THE ENGINE.
(2)
Put a container below the scavenge filter.
S 034-004-C00
(3)
Remove the threaded bowl and permit the oil to drain.
(a) Discard the O-ring.
S 034-005-C00
(4) Remove the filter element from the valve housing.
(a) Discard the filter element and O-ring.
NOTE: When you open the filter element, you will see
____ particles that the filter element has trapped. These particles can indicate early oil wetted distress of the part. If you find a large quantity of particles in the filter, it is recommended to do, if not already done, a check of the magnetic chip detectors to identify the source of the particle contamination. It is recommended also that the particles trapped by the filter be sent to a laboratory for further analysis (refer to NDTM Part 10).
TASK 79-21-04-404-006-C00
3. Install the Scavenge Oil Filter Element_______________________________________
A. Equipment
(1) Crocus Cloth - 200 grit, local purchase
B. Consumable Materials
(1) DOO599, 0il, (CP2442) engine - CFMI SB 79-001
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
79-21-04
ALL ú ú C02 Page 404 ú Mar 15/99
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
(2) G02353, Lubricant, (CP2854) Petrolatum - VV-P-236
C. References
(1)
AMM 12-13-11/301, Engine Oil Servicing
(2)
AMM 71-00-00/501, Power Plant
(3)
AMM 71-11-02/201, Fan Cowl Panel
(4)
AMM 79-21-03/401, Clogging Indicator
D. Access
(1)
Location Zones
506 Engine No. 1
606 Engine No. 2
(2)
Access Panels
5737L/5746L Engine No. 1 - Fan Cowl Assembly
5837R/5846R Engine No. 2 - Fan Cowl Assembly
E. Procedure (Fig. 401)
S 434-020-C00
(1) Examine the chamfered edge of the filter head assembly for nicks or
gouges which can cause O-ring damage.
(a) Make the edge smooth with grade 200 crocus cloth.
S 434-007-C00
CAUTION:_______MAKE SURE YOU INSTALL THE O-RING. IF YOU DO NOT INSTALL THE
O-RING, OIL LEAKAGE AND POSSIBLE ENGINE DAMAGE CAN OCCUR.
(2)
Install a new O-ring, lightly lubricated with engine oil, into the
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：737-300 400 500 AMM 飞机维护手册 滑油 OIL(33)
