Doc # 6.02.01 Page 203
Rev. 4 09 Jan 2003
79-00-00
AMM
Intentionally left blank
79-00-00
Oil System
AMM
% Section 79-01 % Oil System - TAE 125 Diesel Engine % 1. General
% This Section tells you about the airframe parts of the engine oil system. These are the only parts that % you can replace except the oil filter. Refer to Chapter 72 for data about the oil filter.
% 2. Engine Oil System
% Figure 1 shows the oil system schematic diagram. Figure 2 shows the component locations. The % engine has the usual wet-sump lubrication system. The bottom part of the engine crankcase makes % the sump. An oil filler tube with a screw cap connects to the crankcase on the left of the engine.
% Two flexible hoses adjacent to the engine oil filter housing connect to the oil radiator. The oil radiator % is located below the engine at the back.
% The oil breather system has an oil pre-separator located on the engine crankcase adjacent to the oil % filler. A flexible hose connects the oil pre-separator to the oil separator. The oil separator is located % at the rear, left of the engine compartment. A flexible hose from the top of the oil separator vents % blow-by gases and any remaining oil mist overboard. A small flexible hose connects the bottom of the % oil separator to the engine sump.
% Breather Line Oil Separator Overboard Vent
%
Oil Pre-Separator
%
%
%
Oil Filler
%
Catch Tank
%
on Turbo-Charger
%
%
%
Auxiliary Oil Pump
%
%
%
%
%
%
%
%
%
Oil Radiator
% Figure 1: Oil System Schematic Diagram %
Doc # 6.02.01 Page 1
Rev. 4 09 Jan 2003
79-01-00
AIRCRAFT AMM
%
%
%
%
%
%
Oil Thermostat Housing
%
%
%
%
Oil Filler
%
%
%
%
%
%
%
%
%
%
Combined
%
Oil Pump
% % % Oil Return from
Turbo-Charger
%
%
Oil Temperature Sensor
%
(behind Oil Filler)
%
%
%
%
%
%
%
%
%
Oil Pressure Sensor
Oil Filter Housing Oil Return from Oil Radiator
Oil Supply to Oil Radiator
Overboard Vent
Oil Separator
Oil Return Line
Oil Pre-Separator Oil Radiator Breather Line
Figure 2: Oil System Component Locations
% An oil pump in the engine takes oil from the sump. The oil flows through a filter and oil thermostat to % the oil radiator. Air passing through the oil radiator cools the oil. The cool oil returns to the engine. Oil % galleries in the engine take the oil to all bearings. If the oil is colder than 80 °C, the oil thermostat % sends the oil directly to the engine oil galleries.
Page 2 Doc # 6.02.01 09 Jan 2003 Rev. 4
79-01-00
Oil System
AMM
% Trouble-Shooting % 1. General
% The table below lists the defects you could have with the oil system. If you have the trouble detailed % in the Trouble column read across to the Possible Cause column. Then do the repair given in the % Repair column.
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
Trouble Possible Cause Repair
Engine oil temperature too high. Air inlet to oil radiator blocked. Oil radiator matrix dirty/blocked. Oil radiator blocked internally. Low oil level. Remove obstruction. Clean oil radiator matrix. Remove oil radiator and flush with clean engine oil. Replace oil radiator. Refill oil. Refer to Section 12-10.
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：钻石40飞机维护手册 DA 40 SERIES AMM 6(17)
