B. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
24-42-00-861-001 Energize the Ground Service Network from the External Power 25-23-46-000-002 Removal of the Door Linings at the AFT Passenger/Crew Doors
R 25-62-44-000-002 Removal of the Escape-Slide Pack-Assembly 52-00-00-481-001 Installation of the Safety Barriers 52-10-00-010-001 Opening of the Passenger/Crew Door 52-10-00-860-001 Special Precautions before Work on the Passenger/Crew
Door
52-13-12-000-002 Removal of the Guide Arms
52-13-11-991-002 Fig. 401
52-13-11-991-004 Fig. 402
52-13-11-991-005 Fig. 403
1EFF : ALL 1 52-13-11Page 401 1 1 Feb 01/04 1 1 1CES 1
3. Job Set-up
__________ Subtask 52-13-11-861-050
A. Aircraft Maintenance Configuration
(1) Energize the ground service network
(Ref. TASK 24-42-00-861-001).
Subtask 52-13-11-010-051
B. Get Access WARNING : DO NOT OPEN THE PASSENGER/CREW DOOR IF THE WIND SPEED IS MORE
_______
THAN 65 KNOTS.
WARNING : BEFORE YOU START WORK ON THE DOOR, MAKE SURE THAT:
_______
-
THE EMERGENCY CONTROL HANDLE IS IN THE DISARMED POSITION WITH THE SAFETY PIN INSTALLED.
-
THE PERCUSSION LEVER OF THE DOOR-DAMPER AND EMERGENCY-OPERATION CYLINDER IS IN THE DISARMED POSITION WITH THE SAFETY PIN INSTALLED.
WARNING : STOP THE OPENING PROCEDURE IF THE RED WARNING LIGHT FLASHES.
_______ RESIDUAL PRESSURE COULD CAUSE THE DOOR TO OPEN WITH A SUDDEN FORCE AND INJURE PERSONS AND/OR DAMAGE THE AIRCRAFT.
(1)
Put the access platform in position at the zone 832 (842).
(2)
Open the aft passenger/crew door 832 (842) (Ref. TASK 52-10-00-010-001).
(3)
Obey the special precautions before you start work on the door (Ref. TASK 52-10-00-860-001).
Subtask 52-13-11-865-050
C. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------
121VU EIS/SLIDES/ARM AND WARN/FLT 15WN P11 121VU EIS/SLIDES/ARM AND WARN/GND 13WN P10 121VU EIS/SDAC1 AND 2/DOOR/DET/PAX 48WV P05
1EFF : ALL 1 52-13-11Page 402 1 1 Feb 01/98 1 1 1CES 1 **ON A/C 001-002,
Subtask 52-13-11-010-050
D. Removal of Components
(1)
Remove the escape slide (Ref. TASK 25-62-44-000-002).
(2)
Remove the door lining panels (Ref. TASK 25-23-46-000-002):
(a)
For the left door: 832GZ, 832FZ, 832EZ, 832DZ, 832CZ, 832BZ, 832AZ.
(b)
For the right door: 842GZ, 842FZ, 842EZ, 842DZ, 842CZ, 842BZ, 842AZ.
(3) Remove the door insulation blankets. R **ON A/C 003-049, 051-099, 101-149, 151-199, 201-299, 301-399, 401-499,
Subtask 52-13-11-010-050-A
D. Removal of Components
(1)
Remove the escape slide/raft (Ref. TASK 25-62-44-000-002).
(2)
Remove the door lining panels (Ref. TASK 25-23-46-000-002):
(a)
For the left door: 832GZ, 832FZ, 832EZ, 832DZ, 832CZ, 832BZ, 832AZ.
(b)
For the right door: 842GZ, 842FZ, 842EZ, 842DZ, 842CZ, 842BZ, 842AZ.
(3)
Remove the door frame lining (Ref. TASK 25-23-45-000-00300) (Ref. TASK 25-23-45-000-00400)).
1EFF : ALL 1 52-13-11Page 403 1 1 Aug 01/05 1 1 1CES 1 1EFF : ALL 1 52-13-11Page 404 1 1 Feb 01/01 1 1 1CES 1
**ON A/C ALL
Subtask 52-13-11-420-053
E. Installation of the Sling (Ref. Fig. 401/TASK 52-13-11-991-002)
(1) Remove the two self-adhesive patches (3) from the hoisting points. Discard the patches.
(2) Remove the two blanking plugs (1) from the door hoisting points.
R R (3) Remove the hoist fitting (2) from the SLING - PASSENGER DOOR (98A52108004001).
(4) Install the hoist fittings (2) on the door housing.
(5) Put the door in the up position.
R (6) Install the SLING - PASSENGER DOOR (98A52108004001) (10) on the door hoist fittings (2).
R R (7) Use the hoist fittings (2) which are on the tool SLING - PASSENGER DOOR (98A52108004001).
(8) If necessary, adjust the cable tension regulator to balance the door.
R (9) Lift the SLING - PASSENGER DOOR (98A52108004001) (10) to remove the weight of the door from the door suspension.
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：A320飞机维护手册 AMM DOORS 舱门2(76)
