R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 315 1401-499, 1Aug 01/05 1 1 1CES 1
B. Consumable Materials
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 04-004 USA MIL-PRF-23827 TYPE I SYNTH.ESTER BASED GREASE HIGH PRESSURE (Ref. 20-31-00)
Material No. 04-024 AIB AIMS 09-06-001 SYNTHETIC GREASE FOR FLAP & SLAT MECHANISM (Ref. 20-31-00)
Material No. 19-003 USA AMS 3819 LINT-FREE COTTON CLOTH (Ref. 20-31-00)
C. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
27-50-00-866-008 Extension of the Flaps on the Ground 27-50-00-866-009 Retraction of the Flaps on the Ground SIL 12-008 (for corrective action) 12-22-27-991-006 Fig. 303
3. Job Set-up
__________
Subtask 12-22-27-941-060
A. Safety Precautions
(1) Put the safety barriers in position.
Subtask 12-22-27-866-060
B. Aircraft Maintenance Configuration
(1)
Extend the flaps fully (Ref. TASK 27-50-00-866-008).
(2)
On panel 114VU, make sure that the LOCKING TOOL - FLAP/SLAT CONTROL LEVER is installed on the flap/slat control lever.
(3)
Put a warning notice on the flap/slat control lever (panel 114VU) to tell persons not to operate the flap system.
(4)
Put the access platform in position under the applicable flap track.
R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 316 1401-499, 1Aug 01/05 1 1 1CES 1
Subtask 12-22-27-865-072
C. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------49VU FLIGHT CONTROLS/FLP/CTL AND MONG/SYS1 6CV B07 121VU FLIGHT CONTROLS/FLP/CTL AND/MONG/SYS2 8CV Q21
4. Procedure
_________
(Ref. Fig. 303/TASK 12-22-27-991-006)
Subtask 12-22-27-640-060
A. Lubricate the Flap Track Carriage Rollers and No.1 Track Lever Arm
CAUTION : BE CAREFUL WHEN YOU DO MAINTENANCE TASKS ON THE WING TRAILING
_______
EDGE:
-
DO NOT CAUSE DAMAGE TO THE ELECTRICAL CABLE RACEWAYS.
-
DO NOT CAUSE DAMAGE TO THE ELECTRICAL CABLE INSTALLATIONS.
-MAKE SURE THAT THE ELECTRICAL CABLES ARE INSTALLED CORRECTLY. INCORRECT INSTALLATION CAN CAUSE DAMAGE.
NOTE : When you do a maintenance task that uses grease, refer to the SIL
____
(Ref. SIL 12-008).
NOTE : Make sure that the greaser ball of each greaser has sealed
____
correctly after lubrication.
(1)
Clean the greasers of the flap track carriage rollers with a clean MISCELLANEOUS (Material No. 19-003).
(2)
Lubricate the flap track carriage rollers with COMMON GREASE (Material No. 04-004) or COMMON GREASE (Material No. 04-024) through the greasers until new grease comes out.
(3)
Remove the unwanted grease from around the greasers with a clean MISCELLANEOUS (Material No. 19-003).
(4)
Clean the greasers of the No.1 track lever arm with a clean MISCELLANEOUS (Material No. 19-003).
(5)
Lubricate the No.1 track lever arm with COMMON GREASE (Material No. 04-004) or COMMON GREASE (Material No. 04-024) through the greasers until new grease comes out.
R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 317 1401-499, 1Aug 01/05 1 1 1CES 1
Flap Track Carriage Rollers and Drive Lever Arm - Lubrication Points Figure 303/TASK 12-22-27-991-006- 12 (SHEET 1)
R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 318 1401-499, 1Aug 01/05 1 1 1CES 1
Flap Track Carriage Rollers and Drive Lever Arm - Lubrication Points Figure 303/TASK 12-22-27-991-006- 22 (SHEET 2)
R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 319 1401-499, 1Aug 01/05 1 1 1CES 1
(6) Remove the unwanted grease from around the greasers of the No.1 track lever arm with a clean MISCELLANEOUS (Material No. 19-003). ________
5. Close-up
Subtask 12-22-27-865-073
A. Remove the safety clip(s) and the tag(s) and close this(these) circuit breaker(s): 6CV, 8CV.
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址:A320飞机维护手册 AMM SERVICING 2(5)