R B. Test R R During aircraft operations on the ground and in flight, it is possible R for fuel to get into the vent/surge-tank. If this occurs during normal R (serviceable) operation the clack valves let the fuel move back into the R related wing-tank. R R If the two clack valves 215QM and 217QM become unserviceable, in the R closed position, fuel can collect in the related vent/surge-tank. The R collected fuel quantity will increase (cumulatively in separate, R successive additions) until the status of the related sensor 28QJ2 R changes from dry to wet. R R This can cause the two related results that follow: R - the ECAM warning 'FUEL R WING TK OVERFLOW' will be given, if in an R applicable flight phase R - the P/BSW-FUEL/CTR TK/R XFR (6QL) FAULT legend will light, if it was R set to the on (pushed in) position.
R NOTE : The FAULT legend of the P/BSW-6QL can come on in the AUTO or the
____ R MAN (fuel transfer) configuration.
R NOTE : You can get more data from the Aircraft Schematic Manual (ASM)
____ R (Ref. ASM 28-26/01) (Ref. ASM 28-46/03) and (Ref. ASM 28-46/04).
R (1) If the FAULT legend of the P/BSW-6QL comes on, set the P/BSW to OFF R (released out) to prevent a possible fuel spill.
R (2) Make sure that the C/Bs 1QL and 2QL are closed.
R NOTE : The 28VDC supplies related to this procedure are as follows:
____ R - C/B-1QL supplies the FAULT indication circuit in the R P/BSW-FUEL/CTR TK/R XFR (6QL). R - C/B-2QL supplies the level sensor 28QJ2 channel in the R FLSCU-2 (9QJ) and the actuator control valve of jet pump 2 R (center-tank, right-side transfer)
R (3) Do the Functional (BITE) Test of the FLSS (Ref. AMM TASK 28-46-00-740-001).
R (4) Examine the FLSS STATUS page for the message 284616 R SURGE SENSOR
R 28QJ2:
R (a) If the message:
R
R - is shown, do step (5) and then step (6)
R
R - is not shown, do step (6).
R (5) Do the TSM procedure (Ref. TASK 28-46-00-810-812).
「一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一1 EFF : 301-399, ∞∞28-26-00∞∞∞∞∞∞∞∞∞∞Page 220
Aug 01/05 CES
R (6) Do the Operational Test of the Main Transfer Control System (Ref. AMM
TASK 28-26-00-710-001).
R
R - if a new fault occurs (or shows during the Operational Test) refer
R to Troubleshooting, Fault Symptoms with the new related fault
R symptom(s) to find the applicable TSM procedure number(s).
R
R - if the test operates as specified, do the steps given in Para. 4.A.
R
4. Fault Isolation_______________
R A. Procedure
R (1) Get access to the right wing fuel-tank inboard side of Rib 22 (Ref.
R AMM TASK 28-12-00-200-001).
R (2) Do a check of (Ref. AMM TASK 28-12-00-200-001) and replace, if
R necessary, the items that follow (Ref. AMM TASK 28-11-42-000-002) and
R (Ref. AMM TASK 28-11-42-400-002):
R - the forward CLACK VALVE (215QM)
R - the rear CLACK VALVE (217QM).
R (3) Do the TSM procedure Unwanted (Spurious) Warnings/Indications
R involving the SDAC-1 (1WV1) (SDAC-2 (1WV2) (Ref. TASK 31-55-00-810-
R 801).
R (4) If the fault continues, do the Fault Isolation Procedures (in Para.
R 4.A.), of the TSM Tasks that follow:
R
R (a) Transfer Control Valve 2 (Right) does not close - (Ref. TASK 28-
26-00-810-805).
R
R (b) Main Transfer System Auto Control Failure - (Ref. TASK 28-26-00-
810-801).
「一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一1 EFF : 301-399, ∞∞28-26-00∞∞∞∞∞∞∞∞∞∞Page 221
Aug 01/05 CES
TASK 28-26-00-810-810
Fuel, Main Transfer System - Left Side Primary Supply Failure or Jet Pump Jet Blocked
WARNING : OBEY THE FUEL SAFETY PROCEDURES.
_______
1. Possible Causes
_______________
- JET PUMP-L, CENTER TANK (157QM)
- FUEL CONTROL VALVE-JET PUMP, L WING TK (153QM)
- primary fuel supply pipe between the left wing fuel pumps and the JET PUMP-LEFT WING TANK (157QM)
2. Job Set-up Information
______________________
A. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION
-------------------------------------------------------------------------------
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：A320 Trouble Shooting Manual 排故手册 FUEL 燃油2(98)
