(a) Install the shim in the floor mount as shown in (Fig. 401).
NOTE: Do not make each shim thicker than 0.06 inch.
____
WARNING: DO NOT GET SOLVENTS IN YOUR MOUTH, OR YOUR EYES, OR ON
_______ YOUR SKIN. DO NOT BREATHE THE FUMES FROM SOLVENTS. SOLVENTS ARE HAZARDOUS MATERIALS. REFER TO PRODUCT MATERIAL SAFETY DATA SHEETS (MSDS) AND LOCAL REQUIREMENTS FOR PROPER HANDLING PROCEDURES.
(b)
Clean the shim and the floor mount surfaces with a clean wiper, which is moist with solvent, Series 91 (AMM 20-30-91/201, SOPM 20-30-91).
(c)
Bond the shim to the floor mount with adhesive and clean the unwanted adhesive.
S 424-095
(4)
Install the screws in the forward wall to attach the lavatory to the flight compartment partition.
S 414-020
(5)
Install the forward floor mount. Apply the sealant around the bolt head after the installation of the bolt.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
25-41-01
ALL ú ú 04 Page 406 ú May 28/99
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
757
MAINTENANCE MANUAL
(6) S 424-096Connect the waste drain line to the lavatory adapter with a clamp.
(7) S 394-022Apply the sealant in the screw holes and install the screws to put the adapter on the lavatory floor. Apply the sealant around the adapter.
(8) S 414-023Install the toilet tank (AMM 38-32-01/401).
(9) S 424-097Connect the water supply line and the water drain line.
S 414-025
(10)
Put the aft wall in position to align the mounts.
S 424-098
(11)
Install the screws to connect the ceiling panel.
S 424-100
(12)
Install the screws along the outboard contour.
S 394-028
(13)
Install the aft floor mount. Apply the sealant around the bolt head after installation of the bolt.
S 414-029
(14)
Put the aisle wall in position for installation.
S 424-099
(15)
Connect the electrical wiring.
S 414-031
(16)
Install the floor mount.
S 424-101
(17)
Install the fasteners that connect the aisle wall to the aft wall.
S 414-033
(18)
Install the trim strips.
S 414-034
(19)
Connect the overhead tie rods.
(20)
Install the mirror.
S 414-035
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
25-41-01
ALL ú ú 04 Page 407 ú May 28/99
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
757 MAINTENANCE MANUAL
S 414-037
(21)
Install the door frame and door (AMM 25-41-02/401).
S 424-102
(22)
Connect the electrical connector above the ceiling.
S 424-103
(23)
Connect the gasper air duct with vinyl plastic tape.
S 394-040
(24)
Apply the sealant between the lavatory walls and airplane floor.
E. Put the Airplane Back to Its Usual Position
S 414-041
(1)
Install the ceiling panels around the lavatory.
S 414-042
(2)
Install the doorway lining (AMM 52-11-02/401).
S 864-065
(3)
Close the fill/overflow valve on the potable water service panel (AMM 38-10-00/201).
S 864-044
(4)
Remove the DO-NOT-CLOSE tag and close this circuit breaker on the P11 panel:
(a) 11S8, LAV FLUSH MOTOR A
S 864-045
(5) Remove the DO-NOT-CLOSE tags and close these circuit breakers on the P34 panel:
(a)
34B6, LIGHT LAV SERVICE
(b)
34D1, LAV LIGHTS OCCUPY DOME
S 864-046
(6) Remove the DO-NOT-CLOSE tag and close this circuit breaker on the P37 panel:
(a) 37G3, LIGHTS LAV
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：757 AMM 飞机维护手册 EQUIPMENT/FURNISHINGS 2(9)
