A. Aircraft Maintenance Configuration
(1) Make sure that the aircraft is in this configuration:
-the spoilers 1 thru 5 retracted,
-all servo controls in their neutral position.
4. Procedure_________
Subtask 29-10-00-220-051
A. Do this Functional Test
R R R (1) Use a ground service cart with a FLOWMETER 20 L.MN (5.2833 US GAL.MN), calibrated to +/- 1.5% over full range to pressurize the Blue hydraulic system (Ref. TASK 29-10-00-863-003).
(2) Make a record of the flow rate.
R (3) Make sure that the flow rate is not more than 7.5 l (1.9812 USgal)/minute.
(4) If the flow rate is too high, do the full check of internal leakage to find the cause (Ref. TASK 29-00-00-280-002).
5. Close-up________
Subtask 29-10-00-860-069
A. Put the aircraft back to the serviceable condition.
(1) Remove the ground service cart and the flow meter from the aircraft.
(2) Depressurize the Blue hydraulic system (Ref. TASK 29-10-00-864-003).
TASK 29-10-00-200-009
Detailed Visual Inspection of Hydraulic Pressure Switch Line (P/N
642-5658-501/505) for Clamp Chafing Damage and Preload Condition
WARNING : OBEY THE HYDRAULIC SAFETY PROCEDURES.
_______
WARNING : DO NOT TOUCH THE HYDRAULIC SYSTEM COMPONENTS FOR A SHORT TIME AFTER
_______ THE ENGINE IS SHUTDOWN. THE ENGINE COMPONENTS STAY HOT FOR SOME TIME AND CAN CAUSE INJURY.
CAUTION : DO NOT LET HYDRAULIC FLUID FALL ON THE ENGINE. UNWANTED HYDRAULIC
_______ FLUID MUST BE REMOVED IMMEDIATELY WITH A CLEAN LINT FREE CLOTH. THE FLUID CAN CAUSE DAMAGE TO THE SURFACE PROTECTION AND TO SOME PARTS.
1. Reason for the Job
__________________
Refer to the MPD TASK: 290000-04
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION
-------------------------------------------------------------------------------
No specific circuit breaker(s) safety clip(s)
No specific warning notice(s)
No specific RL-6000-SAEL 1.00 inch. (25.4 mm) wide self adhering
silicone tape
No specific access platform 0.8 m (2 ft. 7 in.)
No specific container 5 l (1.3208 USgal)
R No specific Torque Wrench : range 5.00 to 35.00 lbf.in R (0.05 to 0.40 m.daN) No specific Torque Wrench : range 96.00 to 900.00 lbf.in
(1.00 to 10.00 m.daN)
B. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
12-12-29-611-001 Fill the Hydraulic Fluid Reservoir with a Hand Pump 12-12-29-611-002 Fill the Hydraulic Fluid Reservoir with a Hydraulic Service Cart 29-00-00-864-001 Put the Related Hydraulic System in the Depressurized
Configuration before Maintenance Action 29-11-00-710-001 Operational Test of the Green Hydraulic System 29-11-49-000-002 Removal of the Hydraulic Pressure Hose/Tube Assembly 29-11-49-000-005 Removal of the Hydraulic Low-Pressure Switch Tube 29-11-49-400-002 Installation of the Hydraulic Pressure Hose/Tube
Assembly 29-11-49-400-005 Installation of the Hydraulic Low-Pressure Switch
Tube
29-13-00-710-002 Operational Test of the Yellow Hydraulic System
29-14-00-614-001 Depressurization of the Hydraulic Reservoirs
71-13-00-010-040 Opening of the Fan Cowl Doors
71-13-00-410-040 Closing of the Fan Cowl Doors
R 29-10-00-991-007 Fig. 603
3. Job Set-up
__________
Subtask 29-10-00-860-095
A. Aircraft Maintenance Configuration
(1)
Make sure that the Green hydraulic system is depressurized and put it in the maintenance configuration. (Ref. TASK 29-00-00-864-001).
(2)
Make sure that the Yellow hydraulic system is depressurized and put it in the maintenance configuration. (Ref. TASK 29-00-00-864-001).
(3)
Depressurize the reservoirs of the Green and Yellow hydraulic systems. (Ref. TASK 29-14-00-614-001).
(4)
Put warning notice(s) in position to tell persons not to pressurize the Green hydraulic system:
-in the cockpit on the hydraulic section 40VU of the overhead panel, - on the ground service panel of the Green hydraulic system.
R 1EFF : ALL 1 29-10-00Page 623 1 1 Feb 01/05 1 1 1CES 1
(5)
Put warning notice(s) in position to tell persons not to pressurize the Yellow hydraulic system:
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：A320飞机维护手册 AMM HYDRAULIC POWER 液压1(123)
