%
H. General
100 hr items marked X* apply to US registered airplanes only Interval
Inspection Items 50 100 200 1000 Time Initials
1. 2. 3. Examine the Pitot-static system. S Clean the Pitot-static system. S Do a Pitot and static leak test. (Refer to Section 34-10). If necessary, inspect optional equipment. Refer to Chapter 9 of the Airplane Flight Manual (Supplements). If necessary, inspect Additional Equipment (equipment which is installed but is not listed in Section 6.5 of the Airplane Flight Manual). X X X X X X X
Doc # 6.02.01 Page 39
Rev. 4 09 Jan 2003
05-20-00
Maintenance Checks
AMM
%
DA 40 Series
100 hr items marked X* apply to US registered airplanes only Interval
Inspection Items 50 100 200 1000 Time Initials
4. Lubricate the airplane. (Refer to Section 12-20). X X X
5. Measure the play in the aileron and elevator controls with the control surfaces locked (Refer to Section 27-30). Look specially for too much play. Do the test at the top of the control stick. S Maximum play allowed ± 2.5 mm (± 0.1 in.). (Refer to Section 27-10). X X X
6. Do a function test of the aileron control system. (Refer to Section 27-10). X X X
7. Do a function test of the rudder control system. (Refer to Section 27-20). X X X
8. Do a function test of the elevator control system. (Refer to Section 27-30). X X X
9. Do an function test of the trim-system. Look specially for incorrect operation and indication. (Refer to Section 27-38). X X X
10. Do a function test of the flap system. (Refer to Section 27-50). Look specially at the pre-load. With the flaps set to UP: S Correct pre-load 3 - 5 daN (6.7 - 11.2 lb) X X X
11. Lower the airplane off jacks. (Refer to Section 07-10). X* X X
12. Do an operational test of the external lights. X X X
13. Do an operational test of the Pitot heat. X X X
05-20-00
AMM
Maintenance Checks
%
%
%
%
DA 40 Series
100 hr items marked X* apply to US registered airplanes only Interval
Inspection Items 50 100 200 1000 Time Initials
14. Examine the airplane. Look specially for loose items and tools. Close all access panels. Install these items: S Engine cowlings. S The instrument panel cover. S The seat shells. S The control-stick boots. S The engine cowlings. X X X X
WARNING: DO NOT LET PERSONS INTO THE DANGER AREA OF THE PROPELLER. PROPELLERS CAN CAUSE INJURY OR DEATH. WARNING: SET THE PARKING BRAKE TO ON. IF YOU DO NOT DO THIS THE AIRPLANE CAN MOVE. THIS CAN CAUSE INJURY OR DEATH.
15. 16. 17. 18. 19. Put the chocks against the main airplane wheels. Do the post maintenance engine test. S For the engine run procedures refer to the Airplane Flight Manual. S Record the data (Refer to Paragraph 7, Engine Ground Test Record). Examine the engine for leakage. Make sure the engine oil filter is tight. (Refer to Section 79-00 for the Lycoming version or Section 79-01 for the TAE version). Do a test flight. Put the engine ground test and the flight test reports in the Airplane Maintenance Log. X X X X X X X X X X X X X X X X X X X
Doc # 6.02.01 Page 41
Rev. 4 09 Jan 2003
05-20-00
Maintenance Checks
AMM
5. Maintenance Report
Complete a copy of the Maintenance Report after all of the applicable maintenance tasks in the Maintenance Checklist have been initialled.
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：钻石40飞机维护手册 DA 40 SERIES AMM 1(52)
