MAINTENANCE MANUAL
starter-generator. At 70 percent speed, the elctronic control unit removes the start signal for the start converter unit. With the start signal off, the SCU and the SPU removes the power from the starter-generator.
TEXT PAGE
Training Information Point
The maximum duty cycle for the SPU and SCU is three starts, on after the other, followed by a 15 minute cool down period. If you do too many starts one after the other the SCU and SPU will get too hot and stop the APU start. More starts are possible after the SCU and SPU cool.
You access the SCU terminal block for the AC power feeder wires from the back of the SCU. You remove the panel behind the E2 rack from the forward cargo compartment to access the back of the SCU.
GRAPHIC PAGE
Page 08 Oct 5/1998 49-40-00 MAINTENANCE MANUAL
EE COMPARTMENT (LOOKING AFT)
ECU (AFT CARGOL) 115V AC TRANSFER BUS 1 OR BATTERY
01-00-00-002 Rev 1 12/23/1998
49-40-00-002 REV 0
49-40-00-002 REV 0
START POWER UNIT (E2-2) APU IGNITION AND. START SYSTEM - SPU AND SCU GENERAL DESCRIPTION
EFFECTIVITY
49-40-00
ALL
Page 09 OCT 5/1998
MAINTENANCE DOCUMENTS - AMM PART 1
01-00-00
- 193 -
ALTEON PROPRIETARY - Copyright (c) - See title page for details
737-600/700/800/900 TRAINING MANUAL MAINTENANCE DOCUMENTS -- AMM PART 2 - INTRODUCTION THIS PAGE INTENTIONALLY LEFT BLANK
01-00-00
MAINTENANCE DOCUMENTS -- AMM PART 2 - INTRODUCTION
General
Part II of the AMM contains the maintenances practices and procedures to do maintenance on the airplane.
Chapter Numbering System
The manual has a tab section for each ATA chapter. Within each tab section, the manual has more divisions that use the assigned subject number (ASN) list number XX-YY-ZZ, where:
-XX is the ATA chapter
-YY is the subsystem or sub-subsystem
-ZZ is the unit (component).
The table of contents for each chapter lists the maintenance procedures in numerical order for each subsystem and sub-subsystem. For each subsystem or sub-subsystem, the maintenance tasks are in alphabetical order based on the page numbers described below.
Page Numbering System
Each page has two numbers in the lower right corner: the ASN and a topic page number. Each topic is made up of a page block. Each page block is for a special type of information. These are the page blocks:
Page Type Page Block
MAINTENANCE PRACTICES (MP) 201-299
SERVICING (SRV) 301-399
737-600/700/800/900 TRAINING MANUAL
Page Type Page Block
REMOVAL/INSTALLATION (R/I) 401-499
ADJUSTMENT/TEST (A/T) 501-599
INSPECTION/CHECK (I/C) 601-699
CLEANING/PAINTING (C/P) 701-799
REPAIRS (AR) 801-899
DISPATCH DEVIATIONS GUIDE (DDG) 901-999
Dispatch Deviation Guide
If all the topics for an ATA chapter, subsystem, or sub-subsystem are brief, all the topics are in a single MAINTENANCE PRACTICES page block.
The dispatch deviations guide page block has procedures with maintenance tasks that prepare the airplane for flight with certain systems/components inoperative. It also has tasks that put the airplane back to its usual condition.
Training Information Point
Each chapter of part II of the AMM has a list of effective pages at the beginning of each chapter.
Training Information Point
Chapter 12 of the AMM has the title SERVICING. This chapter has procedures to fill and drain items such as:
-Fuel
-Oil
01-00-00-003 Rev 1 11/16/1996
- 195 -
01-00-00
737-600/700/800/900 TRAINING MANUAL
MAINTENANCE DOCUMENTS -- AMM PART 2 - INTRODUCTION
-Hydraulic fluid
-Water
-Tire pressure.
01-00-00
737-600/700/800/900 TRAINING MANUAL
01-00-00-003 Rev 1 12/23/1998
ASN
PAGE BLOCK
MAINTENANCE DOCUMENTS - AMM PART 2 - INTRODUCTION
01-00-00
737-600/700/800/900 TRAINING MANUAL MAINTENANCE DOCUMENTS -- AMM PART 2 - MAINTENANCE TASK STRUCTURE THIS PAGE INTENTIONALLY LEFT BLANK
01-00-00
737-600/700/800/900 TRAINING MANUAL MAINTENANCE DOCUMENTS -- AMM PART 2 - MAINTENANCE TASK STRUCTURE
General
The maintenance tasks are procedures for specific maintenance requirements. For example, R/I page blocks normally contain two tasks: removal of the LRU and installation of the LRU.
Each procedure has some or all of these paragraphs:
-General
-Equipment
- Consumable materials
- References
- Access
-Prepare for removal
-Procedure
中国航空网 www.aero.cn
航空翻译 www.aviation.cn
本文链接地址：737-600/700/800/900培训手册 TRAINING MANUAL 1(41)
